All work will be performed at the contractor's facility. This vessel is geographically restricted to 576 Nautical Miles one way, or 1,152 Nautical Miles, round-trip from the cutters homeport of Miami, FL. The performance period will be EIGHTY (80) calendar days with a start date of 13 July through 30 September 2011.
The scope of the acquisition is for the Drydocking and repairs of the USCGC CUSHING (WPB-1321), an 110 Foot "B" Class Patrol Boat. This work will include, but is not limited to:
1.Hull Plating (U/W Body), Ultrasonic Testing
2. Steel Hull and Structural Plating Repairs
3. Steel Hull and Structural Plating Repairs
4. Appendages (U/W), Leak Test
5. Propulsion Shaft Rope Guards, Inspect and Repair
6. Appendages (U/W) - Internal, Preserve
7. Tanks (MP Fuel Service), Clean
8. Tanks (MP Fuel Stowage and Overflow), Clean
9. Tanks (MP Fuel Service), Inspect
10. Tanks (MP Fuel Stowage and Overflow), Inspect
11. Tanks (Potable Water), Clean and Inspect
12. Tanks (Dirty Oil and Waste), Clean and Inspect
13. Propulsion System, Alignment Check
14. Propulsion Shafting, Remove, Inspect, and Reinstall
15. Mechanical Shaft Seal Assemblies, Overhaul
16. Propulsion Shaft Bearings (External), Check Clearances
17. Propulsion Shaft Bearings (External), Renew
18. Propellers, Remove, Inspect, and Reinstall
19. Propeller, Repair Root Erosion
20. Exhaust System, MDE, Inspect
21. SW Heat Exchangers, Clean, Inspect and Hydro
22. Fathometer Transducer, Renew
23. Speed Doppler, Renew, Doppler Valve, Overhaul
24. Sea Valves and Waster Pieces, Overhaul or Renew
25. Sea Strainers - Duplex (All Sizes), Overhaul
26. Firemain Valves, Renew
27. Bilge and Ballast Valves, Overhaul or Renew
28. Rudder Assemblies, Remove, Inspect and Reinstall
29. Fin Stabilizers (General), Overhaul
30. Grey Water Holding Tanks, Clean and Inspect
31. Sewage Holding Tanks, Clean and Inspect
32. Grey Water Piping, Clean and Flush
33. Sewage Piping, Clean and Flush
34. Battery Space, Preserve and Insulate
35. Aft Steering Compartment, Preserve and Insulate
36. Forward Void, Preserve
37. Tanks (Dirty Oil and Waste), Preserve "100%"
38. Tanks (Grey Water Holding), Preserve "100%"
39. Tanks (Potable Water), Preserve "100%"
40. Tanks (Sewage Holding), Preserve "100%"
41. Bilge Surfaces, Preserve
42. Decks - Exterior, Preserve ("Non-Skid Broadcast Grit" System)
43. U/W Body, Preserve ("100%")
44. Stern Tube Interior Surfaces, Preserve 100%
45. Cathodic Protection System (Bilge and Sea Chest), Renew
46. Cathodic Protection System, Inspect and Maintain
47. Impressed Current Cathodic Protection System Dielectric Shield, Renew
48. Drydocking
49. Temporary Services, Provide
50. Sea Trial Performance, Provide Support
51. Hull Plating and Structural Members, Inspect and Repair
52. Deck Plating, Renew (Aluminum)
53. Canopy Mounts, AMIO, Fabricate and Install
54. CCTV Security System, Install
55. Main Reduction Gear Assembly, Remove, Reinstall and Realign
56. Through.eck Packing Gland, Insulation and Carpeting, Renew
57. Deck Covering (Interior Wet/Dry), Renew
58. Deck Covering (Wet/Dry), Seal
All welding and brazing shall be accomplished by trained welders who have been certified by the applicable regulatory code performance qualification procedures. In accordance with FAR 19.1305, if your firm is HUBZone certified or FAR 19.1404 if you firm is SDVOSB or FAR 19.501 if your firm is a Small Business and intends to submit an offer on this acquisition, please respond by e-mail to [email protected] or by fax (757) 628-4676. Questions may be referred to Susan Kreider at (757) 628-4644.
In response please include the following: (a) a positive statement of your intent to submit a bid for this solicitation as a prime contractor; (b) evidence of experience in work similar in type and scope to include contract numbers, project titles, dollar amounts, points of contact and telephone numbers; (c) past performance references with points of contact and phone numbers, at least two (2) references are requested, but more are desirable.
Your response is required by January 26, 2011. All of the above must be submitted in sufficient detail for a decision to be made on a HUBZone, Service-Disabled Veteran-owned Small Business set aside or Small Business set aside. Failure to submit all information requested may result in an unrestricted acquisition. A decision on whether this will be pursued as a HUBZone or SDVOSB small business set aside, or a Small Business set aside, will be posted on the FedBizOps website at http://www.fedbizopps.gov.