This is a combined synopsis/solicitation for commercial items prepared IAW the format in FAR Subpart 12.6 as supplemented with additional information included in this notice. This announcement constitutes the only solicitation. Quotes are being requested and an additional written solicitation will not be issued. This is a Request For Quotation (RFQ). The solicitation document and incorporated provisions and clauses are those in effect through Federal Acquisition Regulation (FAR) and Supplements, Federal Acquisition Circular (FAC) 2005-59 and DFARs Change Notice (DPN) 20120420. NAICS is 334519 with a small business size standard of 500 employees.

This acquisition is a 100% small business set-aside.

The Air Force Flight Test Center (AFFTC), at Edwards AFB, CA is seeking potential sources capable of providing a SPECTRUM SENSORS & CONTROLS, INC.: TRIAXIAL ANALOG ACCELEROMETER, P/N 34200B-3152; and TRIAXIAL RATE GYRO, P/N 31206B-3317, which includes the following Specifications:

BRAND NAME OR EQUAL TO:

SPECTRUM SENSORS & CONTROLS, INC.
1. QUANTITY OF THREE (3) EACH, TRIAXIAL ANALOG ACCELEROMETER, P/N 34200B-3152.
2. QUANTITY OF THREE (3) EACH, TRIAXIAL RATE GYRO, P/N 31206B-3317.

MINIMUM SALIENT CHARACTERISTICS

TRIAXIAL ANALOG ACCELEROMETER, SPECIAL
RANGE: +/- 10G
BANDWIDTH: 6.6 HZ
TERMINATION: 4 FOOTCABLE W/ D-SUB
- CONNECTOR 5
SPECIAL 24AWG CABLE W/FEP JACKET
- PER 34200B-3152 DRAWING
INCLUDES STANDARD & TEMPERATURE
- CALIBRATION CERTIFICATE
Parameter Min Typical Max Units Conditions/Notes
Range
Measurement Full Scale ±10 ±70 g On each axis. Must specify via Option Rnnn
Sensitivity
At 25°C, Option R050
Drift Tmin to Tmax 38†
±0.5 mV/g
% Precise values on cal certificate
Percent of sensitivity at 25°C
Zero g Bias Level
At 25°C
Drift Tmin to Tmax 2.5
±60 V
mg Precise values on cal certificate
At 1.25°C/min temperature rate of change
Alignment
Deviation from Ideal Axes ±0.2 ±0.5 degrees Precise values on cal certificate
Can be compensated if required
Transverse Sensitivity ±0.25 % Inherent sensor error, excluding misalignment
Nonlinearity 0.2 2 % FSR Best fit straight line
Frequency Response 0 400†† Hz Upper cutoff per Option Bnnn, -3 dB pt ±10%
Noise Density
Option R070
Option R050, R040
Option R035, R030, R025, R020, R015, R010 1.8 3.5
1.4 3.0
1.1 3.0 mg/√Hz
mg/√Hz
mg/√Hz 10 Hz to 400 Hz
Self-Test Input Impedance 10 kΩ Pullup. Logic "1"≥ 3.5 V, Logic "0"≤ 1.5 V
Temperature Sensor
Sensitivity
0°C Bias Level 6.45
509 mV/°C
mV Accuracy ±1°C
Outputs
Output Voltage Swing
Capacitive Drive Capability 0.25 4.75 1000 V
pF Iout = ±0.5 mA
Power Supply (Vs)
Input Voltage Limits
Input Voltage - Operating
Input Current
Rejection Ratio -20 +38
+8.5 +36
15 20
>120 V
V
mA
dB -20 V continuous
No load, quiescent
DC
Temperature Range (Ta) -40 +85 °C
Mass 35 grams Precise values on cal certificate
Shock Survival -4000 +4000 g Any axis for 0.5 ms, powered or unpowered

TRIAXIAL RATE GYRO, SPECIAL
TERMINATION: 4 FT CABLE W/6 9-PIN MALE
- DSUB CONNECTOR
SPECIAL 24AWG CABLE W/FEP JACKET
- PER 31206B-3XXX1 DRAWING

Range & Sensitivity at 25°C
±600°/sec FSR
±300°/sec FSR
±150°/sec FSR
±50°/sec FSR
Drift Tmin to Tmax 2.8 3.1 3.4
5.6 6.3 6.9
11.2 12.5 13.8
22.5 25 27.5
2.5 mV/°/sec
mV/°/sec
mV/°/sec
mV/°/sec
% FSR Must specify via Option Rnnn, see Ordering Info
Precise values on cal certificate
Precise values on cal certificate
Precise values on cal certificate
Precise values on cal certificate
Zero g Bias Level
At 25°C
Drift Tmin to Tmax 2.50
±3.0 ±6.0 V
°/sec Precise values on cal certificate
Alignment
Deviation from Ideal Axes ±1.5 degrees Precise values on cal certificate
Can be compensated if required
g Sensitivity 0.2 °/sec/g Affects offset
Nonlinearity 0.1 % FSR Best fit straight line
Frequency Response 0 100 Hz Upper cutoff per Option Bnnn, -3 dB pt ±10%
Noise Density 0.05 °/sec/√Hz Ta = 25°C
Self Test Input Impedance 10 kΩ Pullup. Logic "1"≥ 3.5 V, Logic "0"≤ 1.5 V
Self Test Response w/ST pin grounded
±600°/sec FSR
±300°/sec FSR
±150°/sec FSR
±50°/sec FSR -0.275
-0.540
-1.0
-1.9 V
V
V
V ±30% may indicate defective axis
Temperature Sensor
Sensitivity
+25°C Bias Level 9.1
2.5 mV/°C
V
Outputs
Output Voltage Swing 0.25 4.75 V Iout = 1 mA, Capacitive load < 1000 pF
Power Supply (Vs)
Input Voltage Limits
Input Voltage - Operating
Input Current
Rejection Ratio -20 +38
+8.5 +36 18 30
>120 V
V
mA
dB -20 V continuous
No load, quiescent
DC
Temperature Range (Ta) -40 +85 °C
Mass 35 grams
Shock Survival -2000 +2000 g Any axis for 0.5 ms, powered or unpowered

SPECIAL
RANGE: AXIS 1, 50°/SEC (PITCH)
RANGE: AXIS 2, 150°/SEC (ROLL)
RANGE: AXIS 3, 50°/SEC (YAW)

Bandwidth 0-50 Hz

Delivery: 3 WARO

Place of delivery, performance, and acceptance is FOB Destination, Edwards AFB, CA 93524.

Interested parties who believe they can meet all the requirements for the items described in this synopsis are invited to submit in writing a complete quote including delivery FOB Destination Edwards AFB, CA 93524. Offerors are required to submit with their quote enough information for the Government to evaluate the minimum requirements detailed in this synopsis.

CONTRACTORS MUST COMPLY WITH FAR 52.204-7 CENTRAL CONTRACTOR REGISTRATION AND DFARS 252.204-7004, ALTERNATE A. INTERESTED CONTRACTORS CAN ACCESS THE CLAUSES BY INTERNET URL: http://farsite.hill.af.mil. TO REGISTER WITH THE CCR, GO TO URL: http://www.ccr.gov/ . ONLINE REPRESENTATIONS AND CERTIFICATIONS APPLICATION (ORCA) MUST BE COMPLETED. USE OF ONLINE REPRESENTATIONS AND CERTIFICATIONS APPLICATION (ORCA) BECAME MANDATORY 1 JANUARY 2005. CONTRACTORS CAN ACCESS ORCA THROUGH CCR BY INTERNET URL: http://www.ccr.gov/ .

The following provisions and clauses apply: Clause 52.211-6 Brand Name or Equal; Provision 52.212-1, Instructions to Offerors--Commercial; Clause 52.212-2 Evaluation-Commercial Items; the following factor shall be used to evaluate offers: Lowest price technically acceptable offer, Technically acceptable is meeting all minimum salient characteristics; clause 52.212-4, Contract Terms and Conditions--Commercial Items; clause 52.212-5, Contract Terms and Conditions Required to Implement Statutes Or Executive Orders--Commercial Items (to include: 52.222-26, Equal Opportunity; 52.222-35, Affirmative Action for Special Disabled and Vietnam Era Veterans; 52.222-36, Affirmative Action for Handicapped Workers; 52.222-37, Employment Reports on Special Disabled Veterans and Veterans of the Vietnam Era; Clause 52.232-33 Mandatory information for electronic funds transfer payment. The following DFARs clauses apply to this acquisition: Clause 252.212-7001, Contract Terms and Conditions Required to Implement Statutes or Executive Orders Applicable to Defense Acquisition of Commercial Items; 252.225-7001 Buy American Act and Balance of Payment Program: The following AFFARS clauses apply to this acquisition: Clause 5352.223-9000, Elimination of Use of Class I Ozone Depleting Materials, 252.211-7003, Item Identification and valuation; 252.232-7010. Levies on Contract Payments; 5352.201-910, Ombudsman; 5352.242-9000,

Offers are due at the Air Force Flight Test Center, Directorate of Contracting, 5 South Wolfe Avenue, Building 2800, Edwards AFB, CA, 93524, not later than June 4, 2012 at 10:00 am EST. E-mail address: [email protected]. Phone: 661-277-5686, Fax: 661-277-0470